Garrett 712120 VNT Hella 6NW 008 412 actuator.
Garrett 712120 VNT Hella 6NW 008 412 actuator.
12-14-2009, 03:28 AM
#64
(12-08-2009, 07:19 PM)300SD81 Final version with a microchip controlling it won't be complete until march 2010, when microchip starts shipping the 795F512H chip i want to use....
Make that over winter break, just checked microchips website and they are shipping samples even tho the chips not for sale yet.
Having a rough time laying out the connections between the pic32 and the ethernet phy on a single layer board though.. why in the world do chip makers never put all the pins on a parallel bus next to each other sequentially!?!?! 
its like they want to force you to use multilayer boards..V3 of the actuator board had a short, and I lifted a trace trying to get rid of it, so I found a way to mount V2 in a case, and added a huge heatsink, just going to use it and hope it dosen't fry, the actuator itself has a built in failsafe if it does.
Sensor board is mostly done, but final exams are seriously getting in the way. Should be finished as soon as I can go home and use my moms reflow *toster* oven again.
(12-07-2009, 02:08 PM)winmutt (yes 300SD81, the other scope I have makes the one you pictured look like a state of the art piece).
Wanna post a picture of that timg? I'd love to see it
(12-07-2009, 02:08 PM)winmutt Good news is that the arduino is outputting PWM at 7.1ms and 5v. The bad news is that its not making the actuator actuate. Pretty dismayed at this point. Am going to redo the whole setup again and verify I don't have any bad wires.....
Thats strange... I'd test the actuator by opening it while unpowered and turning the motor off the open position by hand, it should return to fully open when power is applied. If that works and your getting the correct pwm on the scope (measured from pin on actuator), I'd say you have a dead actuator...
This post was last modified: 12-14-2009, 03:48 AM by 300SD81.
Ich liebe meine Autos!
1981 Mercedes-Benz 300SD | 156K Miles | 2nd Owner | EGR Disabled [Removal Pending] | ALDA Removed | Straight Pipes | GT2256V??? | Laser Interceptor | Engine swap over summer, hopefully with GT2256V attached...
1981 Mercedes-Benz 300SD | Odo Stopped at 160K (at least 50K more) | EGR Disabled | ALDA All The Way Out | Straight pipes | FM-870 Remote Start Alarm System | B100 Biodiesel | AC Fixed x2 | Trunk crushed in
| Retired to garage.Excessive speeding? It ain't excessive till I redline!
(12-08-2009, 07:19 PM)300SD81 Final version with a microchip controlling it won't be complete until march 2010, when microchip starts shipping the 795F512H chip i want to use....
Make that over winter break, just checked microchips website and they are shipping samples even tho the chips not for sale yet.
Having a rough time laying out the connections between the pic32 and the ethernet phy on a single layer board though.. why in the world do chip makers never put all the pins on a parallel bus next to each other sequentially!?!?! its like they want to force you to use multilayer boards..V3 of the actuator board had a short, and I lifted a trace trying to get rid of it, so I found a way to mount V2 in a case, and added a huge heatsink, just going to use it and hope it dosen't fry, the actuator itself has a built in failsafe if it does.
Sensor board is mostly done, but final exams are seriously getting in the way. Should be finished as soon as I can go home and use my moms reflow *toster* oven again.
(12-07-2009, 02:08 PM)winmutt (yes 300SD81, the other scope I have makes the one you pictured look like a state of the art piece).
Wanna post a picture of that timg? I'd love to see it
(12-07-2009, 02:08 PM)winmutt Good news is that the arduino is outputting PWM at 7.1ms and 5v. The bad news is that its not making the actuator actuate. Pretty dismayed at this point. Am going to redo the whole setup again and verify I don't have any bad wires.....
Thats strange... I'd test the actuator by opening it while unpowered and turning the motor off the open position by hand, it should return to fully open when power is applied. If that works and your getting the correct pwm on the scope (measured from pin on actuator), I'd say you have a dead actuator...
Ich liebe meine Autos!
1981 Mercedes-Benz 300SD | 156K Miles | 2nd Owner | EGR Disabled [Removal Pending] | ALDA Removed | Straight Pipes | GT2256V??? | Laser Interceptor | Engine swap over summer, hopefully with GT2256V attached...
1981 Mercedes-Benz 300SD | Odo Stopped at 160K (at least 50K more) | EGR Disabled | ALDA All The Way Out | Straight pipes | FM-870 Remote Start Alarm System | B100 Biodiesel | AC Fixed x2 | Trunk crushed in
| Retired to garage.Excessive speeding? It ain't excessive till I redline!
Messages In This Thread
Garrett 712120 VNT Hella 6NW 008 412 actuator. - by tomnik - 08-18-2009, 09:13 AM
RE: electronic actuator? - by Tymbrymi - 08-25-2009, 01:15 PM
RE: electronic actuator? - by tomnik - 08-27-2009, 07:15 AM
RE: electronic actuator? - by winmutt - 09-01-2009, 09:01 AM
RE: electronic actuator? - by Tymbrymi - 09-01-2009, 09:28 AM
RE: electronic actuator? - by winmutt - 09-01-2009, 03:51 PM
RE: electronic actuator? - by tomnik - 09-01-2009, 09:49 AM
RE: electronic actuator? - by Tymbrymi - 09-03-2009, 08:31 AM
RE: electronic actuator? - by winmutt - 09-03-2009, 01:18 PM
RE: electronic actuator? - by Tymbrymi - 09-03-2009, 01:32 PM
RE: electronic actuator? - by winmutt - 09-03-2009, 02:23 PM
RE: Garrett VNT Hella actuator. - by winmutt - 09-04-2009, 08:21 AM
RE: Garrett VNT Hella actuator. - by Tymbrymi - 09-04-2009, 11:30 AM
RE: Garrett VNT Hella actuator. - by winmutt - 09-04-2009, 03:17 PM
RE: Garrett VNT Hella actuator. - by winmutt - 09-04-2009, 12:29 PM
RE: Garrett VNT Hella actuator. - by Tymbrymi - 09-04-2009, 01:36 PM
RE: Garrett VNT Hella actuator. - by winmutt - 09-05-2009, 10:26 AM
RE: Garrett VNT Hella actuator. - by Tymbrymi - 09-05-2009, 10:14 PM
RE: Garrett VNT Hella actuator. - by winmutt - 10-22-2009, 11:22 PM
RE: Garrett VNT Hella actuator. - by Tymbrymi - 10-23-2009, 09:55 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 09-05-2009, 10:49 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 09-08-2009, 10:12 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 09-08-2009, 02:21 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Tymbrymi - 09-09-2009, 08:38 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 09-09-2009, 10:28 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 09-10-2009, 08:02 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by ForcedInduction - 09-14-2009, 04:09 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 10-19-2009, 02:29 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 10-20-2009, 10:51 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 10-23-2009, 01:41 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Tymbrymi - 10-23-2009, 03:51 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 10-27-2009, 08:42 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Tymbrymi - 10-28-2009, 09:48 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 10-28-2009, 10:34 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 10-27-2009, 11:36 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 10-29-2009, 12:21 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Tymbrymi - 10-29-2009, 02:12 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 10-29-2009, 05:01 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 10-29-2009, 12:38 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 10-29-2009, 02:06 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by piledriver - 10-29-2009, 08:07 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Tymbrymi - 10-29-2009, 09:29 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 10-30-2009, 08:25 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 11-02-2009, 11:25 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 11-03-2009, 03:48 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 11-03-2009, 04:01 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Tymbrymi - 11-05-2009, 10:32 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 11-04-2009, 04:53 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 11-04-2009, 09:36 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 11-05-2009, 12:26 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 11-05-2009, 01:38 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 11-06-2009, 04:22 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by muuris - 01-12-2010, 10:58 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 01-12-2010, 04:07 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by muuris - 01-13-2010, 05:39 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 11-08-2009, 03:40 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 11-09-2009, 02:40 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 11-14-2009, 05:00 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by cell - 11-19-2009, 03:35 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 11-21-2009, 03:32 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by ForcedInduction - 11-21-2009, 05:01 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by nockter - 12-05-2009, 01:40 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 12-07-2009, 02:08 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by lars - 12-08-2009, 05:25 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 12-08-2009, 11:21 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 12-08-2009, 07:19 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 12-14-2009, 03:28 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 01-12-2010, 04:45 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by kmaser - 01-12-2010, 05:52 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by cell - 01-23-2010, 08:09 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Kiwibacon - 01-23-2010, 08:23 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by cell - 01-23-2010, 08:25 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 01-26-2010, 04:02 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by ForcedInduction - 02-07-2010, 07:25 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 02-08-2010, 10:41 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by ForcedInduction - 02-11-2010, 02:13 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 02-18-2010, 10:36 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by cell - 02-19-2010, 01:30 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 03-30-2010, 01:19 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by racerxoffl - 10-19-2010, 11:39 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by TB206HDI - 09-23-2010, 02:56 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by dgn555 - 09-23-2010, 02:24 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 09-23-2010, 03:05 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by dgn555 - 10-03-2010, 06:53 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Darqs - 12-01-2010, 03:46 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 12-01-2010, 10:39 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Darqs - 12-02-2010, 02:58 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Tymbrymi - 12-02-2010, 07:48 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Darqs - 12-02-2010, 09:07 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 12-02-2010, 10:03 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Tymbrymi - 12-02-2010, 12:31 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Darqs - 12-08-2010, 06:31 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Biohazard - 12-01-2010, 10:53 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Biohazard - 12-06-2010, 01:32 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Captain America - 12-07-2010, 04:07 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 12-08-2010, 10:25 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Darqs - 12-09-2010, 02:24 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 12-09-2010, 11:32 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Darqs - 12-15-2010, 03:22 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 12-15-2010, 09:14 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Darqs - 12-17-2010, 03:49 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Pali - 04-15-2011, 07:20 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by tomnik - 04-15-2011, 08:03 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Pali - 04-16-2011, 02:44 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Darqs - 04-21-2011, 03:38 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300D50 - 12-15-2010, 09:10 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Biohazard - 12-16-2010, 11:49 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300D50 - 12-16-2010, 11:55 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Biohazard - 12-16-2010, 03:43 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300D50 - 12-16-2010, 06:50 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Biohazard - 12-16-2010, 08:35 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300D50 - 12-17-2010, 11:03 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Biohazard - 12-17-2010, 11:09 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Biohazard - 12-20-2010, 10:21 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Biohazard - 01-16-2011, 10:42 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Darqs - 01-18-2011, 02:37 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Biohazard - 01-18-2011, 09:52 AM
It's the "post your actuator guts" thread now - by aaa - 04-15-2011, 02:41 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by tomnik - 04-17-2011, 11:25 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Pali - 04-18-2011, 01:30 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by tomnik - 04-18-2011, 02:25 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Pali - 04-18-2011, 02:59 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 04-18-2011, 11:47 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 04-18-2011, 09:29 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Pali - 04-19-2011, 02:33 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by 300SD81 - 04-19-2011, 09:16 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Pali - 04-20-2011, 08:39 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 04-20-2011, 08:48 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Pali - 04-21-2011, 03:01 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Darqs - 07-01-2011, 04:07 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by winmutt - 07-01-2011, 03:57 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Darqs - 07-05-2011, 02:21 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by janus - 01-25-2012, 02:45 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Darqs - 02-20-2012, 04:20 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by janus - 01-29-2012, 11:16 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Rub87 - 01-29-2012, 02:47 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by majesty78 - 01-30-2012, 04:21 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Rub87 - 01-30-2012, 05:03 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by janus - 01-30-2012, 01:45 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by janus - 02-20-2012, 11:13 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Darqs - 02-22-2012, 05:42 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by janus - 07-17-2012, 07:03 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Darqs - 09-25-2012, 03:46 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by janus - 07-18-2012, 05:25 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by raysorenson - 07-18-2012, 10:56 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by janus - 10-09-2013, 08:58 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by pemtek - 11-04-2013, 06:22 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by janus - 11-05-2013, 01:47 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by pemtek - 11-05-2013, 03:49 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Iangiulu - 07-10-2014, 02:06 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Iangiulu - 07-12-2014, 02:42 PM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by Darqs - 12-18-2014, 03:06 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by antonmies - 01-23-2015, 06:43 AM
RE: Garrett 712120 VNT Hella 6NW 008 412 actuator. - by HoleshotHolset - 04-15-2015, 10:37 AM
Users browsing this thread:
2 Guest(s)
2 Guest(s)
Users browsing this thread:
2 Guest(s)
2 Guest(s)