Intercooler picture thread?
Intercooler picture thread?
09-04-2013, 11:05 PM
#32
(09-03-2013, 11:26 AM)1911diesel i think the idea of the extra cooler system is to keep temps cooler. altho a w/a intercooler will not bring charge air temps lower then "out side" temps unless its hooked up to the ac system or an ice tank. but generally speaking, it wont cool as well as a a/a intercooler. and when you go hooking it to something thats already hot, like engine or tranny cooling fluids, you are just reducing the efficiency. im sure it would work, just not as well as it could.
You dont "hook into" them. If using coolant you use 1mm bleed holes just to keep the levels between the engine cooling system and the A/W cooling system equal. You keep 1 fill point that way instead of having 2... but they are still separate.
Here is mine
Had to make new turnbuckles, Rudolf's were garbage
(09-04-2013, 08:57 PM)raysorenson(09-03-2013, 05:03 PM)MFSuper90 Actually W/A intercoolers are more efficient than A/A.
When you say "more efficient", are you speaking in terms of thermal capacity, the rate at which the system sheds heat to the air or restriction?
I would say capacity is much more and rate of change is much less with water
This post was last modified: 09-04-2013, 11:06 PM by Captain America.
1982 300D Turbo ... 3,6xxlbs, No fan, No AC, Hood Stack, No ALDA, No rear bumper and stuffed front, A/W Intercooled, Injectors by Greezer and HUGE Pre-Chambers with help from OM616 & Simpler=Better, Fuel Cranked up, 60 Trim Compressor wheel, EGT, EMP, Boost 50" Rigid Radius bar on roof Aux tank for a total of 48 Gal Of Diesel! Odyssey PC-1750 Battery in trunk, 27"x8.5"/R14 Maxxis BigHorn Mud Terrains, In June '14 issue of Off Road Mag
AX15 Jeep Trans swap in progress....
Captain America
09-04-2013, 11:05 PM #32(09-03-2013, 11:26 AM)1911diesel i think the idea of the extra cooler system is to keep temps cooler. altho a w/a intercooler will not bring charge air temps lower then "out side" temps unless its hooked up to the ac system or an ice tank. but generally speaking, it wont cool as well as a a/a intercooler. and when you go hooking it to something thats already hot, like engine or tranny cooling fluids, you are just reducing the efficiency. im sure it would work, just not as well as it could.
You dont "hook into" them. If using coolant you use 1mm bleed holes just to keep the levels between the engine cooling system and the A/W cooling system equal. You keep 1 fill point that way instead of having 2... but they are still separate.
Here is mine
Had to make new turnbuckles, Rudolf's were garbage
(09-04-2013, 08:57 PM)raysorenson(09-03-2013, 05:03 PM)MFSuper90 Actually W/A intercoolers are more efficient than A/A.
When you say "more efficient", are you speaking in terms of thermal capacity, the rate at which the system sheds heat to the air or restriction?
I would say capacity is much more and rate of change is much less with water
1982 300D Turbo ... 3,6xxlbs, No fan, No AC, Hood Stack, No ALDA, No rear bumper and stuffed front, A/W Intercooled, Injectors by Greezer and HUGE Pre-Chambers with help from OM616 & Simpler=Better, Fuel Cranked up, 60 Trim Compressor wheel, EGT, EMP, Boost 50" Rigid Radius bar on roof Aux tank for a total of 48 Gal Of Diesel! Odyssey PC-1750 Battery in trunk, 27"x8.5"/R14 Maxxis BigHorn Mud Terrains, In June '14 issue of Off Road Mag
AX15 Jeep Trans swap in progress....
Messages In This Thread
Intercooler picture thread? - by lgreeley83 - 06-08-2013, 06:59 PM
RE: Inter cooler picture thread? - by winmutt - 06-10-2013, 09:42 AM
RE: Inter cooler picture thread? - by lgreeley83 - 06-10-2013, 02:40 PM
RE: Inter cooler picture thread? - by winmutt - 06-10-2013, 05:09 PM
RE: Inter cooler picture thread? - by Druk - 06-10-2013, 04:48 PM
RE: Inter cooler picture thread? - by MFSuper90 - 06-10-2013, 09:18 PM
RE: Inter cooler picture thread? - by lgreeley83 - 06-10-2013, 09:36 PM
RE: Inter cooler picture thread? - by lgreeley83 - 06-10-2013, 10:47 PM
RE: Inter cooler picture thread? - by MFSuper90 - 06-11-2013, 10:26 AM
RE: Inter cooler picture thread? - by winmutt - 06-11-2013, 06:57 PM
RE: Inter cooler picture thread? - by winmutt - 06-11-2013, 07:12 PM
RE: Inter cooler picture thread? - by MFSuper90 - 06-11-2013, 09:56 PM
RE: Inter cooler picture thread? - by winmutt - 06-12-2013, 10:18 AM
RE: Inter cooler picture thread? - by lgreeley83 - 06-16-2013, 10:02 PM
RE: Inter cooler picture thread? - by swampmonkey - 06-21-2013, 02:28 AM
RE: Inter cooler picture thread? - by lgreeley83 - 06-21-2013, 09:26 AM
RE: Inter cooler picture thread? - by winmutt - 07-04-2013, 08:59 AM
RE: Inter cooler picture thread? - by Captain America - 07-07-2013, 07:22 PM
RE: Inter cooler picture thread? - by winmutt - 07-07-2013, 08:10 PM
RE: Inter cooler picture thread? - by lgreeley83 - 07-07-2013, 09:24 PM
RE: Inter cooler picture thread? - by sassparilla_kid - 07-08-2013, 02:27 PM
RE: Inter cooler picture thread? - by Captain America - 07-08-2013, 02:36 PM
RE: Inter cooler picture thread? - by sassparilla_kid - 07-11-2013, 06:17 PM
RE: Inter cooler picture thread? - by lgreeley83 - 07-11-2013, 07:22 PM
RE: Intercooler picture thread? - by winmutt - 08-30-2013, 10:46 AM
RE: Intercooler picture thread? - by Jambo - 09-03-2013, 06:19 AM
RE: Intercooler picture thread? - by 1911diesel - 09-03-2013, 11:26 AM
RE: Intercooler picture thread? - by MFSuper90 - 09-03-2013, 05:03 PM
RE: Intercooler picture thread? - by 1911diesel - 09-03-2013, 06:38 PM
RE: Intercooler picture thread? - by Captain America - 09-04-2013, 11:05 PM
RE: Intercooler picture thread? - by 85-300D - 09-05-2013, 10:21 AM
RE: Intercooler picture thread? - by Captain America - 09-06-2013, 02:39 AM
RE: Intercooler picture thread? - by larsalan - 09-03-2013, 04:29 PM
RE: Intercooler picture thread? - by raysorenson - 09-04-2013, 08:57 PM
RE: Intercooler picture thread? - by sassparilla_kid - 09-05-2013, 02:13 PM
RE: Intercooler picture thread? - by 85-300D - 09-05-2013, 07:52 PM
RE: Intercooler picture thread? - by MFSuper90 - 09-06-2013, 02:32 PM
RE: Intercooler picture thread? - by lgreeley83 - 10-03-2013, 05:01 PM
RE: Intercooler picture thread? - by MFSuper90 - 10-05-2013, 10:24 AM
RE: Intercooler picture thread? - by winmutt - 09-06-2013, 07:03 PM
RE: Intercooler picture thread? - by sassparilla_kid - 09-06-2013, 07:47 PM
RE: Intercooler picture thread? - by larsalan - 09-06-2013, 10:21 PM
RE: Intercooler picture thread? - by MFSuper90 - 09-07-2013, 02:57 PM
RE: Intercooler picture thread? - by 1911diesel - 09-07-2013, 03:22 PM
RE: Intercooler picture thread? - by JarrusJenkins - 09-08-2013, 07:20 AM
RE: Intercooler picture thread? - by MFSuper90 - 09-08-2013, 10:59 AM
RE: Intercooler picture thread? - by winmutt - 09-08-2013, 09:41 AM
RE: Intercooler picture thread? - by Hario' - 10-02-2013, 04:23 PM
RE: Intercooler picture thread? - by Tito - 10-03-2013, 01:11 PM
RE: Intercooler picture thread? - by mike-81-240d - 10-11-2013, 07:01 PM
RE: Intercooler picture thread? - by winmutt - 10-14-2013, 04:03 PM
RE: Intercooler picture thread? - by mikes02ls1 - 10-16-2013, 01:38 AM
RE: Intercooler picture thread? - by raysorenson - 10-16-2013, 01:55 PM
RE: Intercooler picture thread? - by winmutt - 10-16-2013, 05:36 PM
RE: Intercooler picture thread? - by Tito - 10-17-2013, 03:29 PM
RE: Intercooler picture thread? - by sassparilla_kid - 10-16-2013, 06:04 PM
RE: Intercooler picture thread? - by Captain America - 10-22-2013, 09:53 PM
RE: Intercooler picture thread? - by Ducos - 10-21-2013, 02:42 PM
RE: Intercooler picture thread? - by 300SD_KY - 02-13-2014, 12:13 PM
RE: Intercooler picture thread? - by MFSuper90 - 02-13-2014, 12:31 PM
RE: Intercooler picture thread? - by winmutt - 02-17-2014, 01:19 PM
RE: Intercooler picture thread? - by led-panzer - 06-04-2014, 08:12 PM
RE: Intercooler picture thread? - by sassparilla_kid - 06-04-2014, 09:17 PM
RE: Intercooler picture thread? - by raysorenson - 06-05-2014, 10:00 PM
RE: Intercooler picture thread? - by yota4life - 06-05-2014, 11:34 PM
RE: Intercooler picture thread? - by Hario' - 03-11-2015, 06:29 PM
RE: Intercooler picture thread? - by Booster - 03-12-2015, 08:04 AM
RE: Intercooler picture thread? - by Tito - 11-26-2015, 04:11 PM
RE: Intercooler picture thread? - by Captain America - 11-26-2015, 04:25 PM
RE: Intercooler picture thread? - by MFSuper90 - 11-27-2015, 12:21 AM
RE: Intercooler picture thread? - by F.R.A.S - 11-27-2015, 02:45 AM
RE: Intercooler picture thread? - by Hario' - 11-27-2015, 01:19 PM
RE: Intercooler picture thread? - by MTUPower - 11-27-2015, 01:30 PM
RE: Intercooler picture thread? - by Keino - 11-27-2015, 04:27 PM
RE: Intercooler picture thread? - by raysorenson - 11-27-2015, 11:32 PM
RE: Intercooler picture thread? - by Tito - 11-28-2015, 12:39 PM
RE: Intercooler picture thread? - by merc85 - 01-08-2016, 07:48 AM
RE: Intercooler picture thread? - by Keino - 01-08-2016, 03:14 PM
RE: Intercooler picture thread? - by Sultzi - 01-09-2016, 04:05 AM
RE: Intercooler picture thread? - by Keino - 01-09-2016, 07:34 AM
RE: Intercooler picture thread? - by soltysrsz - 01-10-2016, 02:46 AM
RE: Intercooler picture thread? - by AlpinaM30B35 - 05-29-2016, 11:12 PM
RE: Intercooler picture thread? - by hents99 - 05-30-2016, 02:02 AM
RE: Intercooler picture thread? - by Dark Hawk - 07-25-2016, 03:55 PM
RE: Intercooler picture thread? - by Sultzi - 07-31-2016, 02:50 AM
RE: Intercooler picture thread? - by Antonio - 05-29-2017, 09:29 AM
RE: Intercooler picture thread? - by winmutt - 10-06-2017, 07:10 AM
RE: Intercooler picture thread? - by HeavyArms - 06-20-2018, 06:51 PM
RE: Intercooler picture thread? - by MTUPower - 04-27-2019, 11:21 AM
RE: Intercooler picture thread? - by nastala - 03-05-2021, 03:40 PM
RE: Intercooler picture thread? - by g wizz - 08-07-2021, 05:51 PM
RE: Intercooler picture thread? - by g wizz - 08-07-2021, 05:49 PM
Users browsing this thread:
4 Guest(s)
4 Guest(s)
Users browsing this thread:
4 Guest(s)
4 Guest(s)